COAL IGNITION AND COMBUSTION RESEARCH FUEL WITH MECHANO – AND PLASMA CHEMICAL ACTIVATION FOR ENERGY

  • S. V. Alekseenko nstitute of Thermophysics named after S.S. Kutateladze SB RAS, Akademika Lavrentiev Ave., 1, Novosibirsk, Russia
  • А. P. Burdukov Institute of Thermophysics named after S.S. Kutateladze SB RAS, Akademika Lavrentiev Ave., 1, Novosibirsk, Russia
  • Е. B. Butakov Institute of Thermophysics named after S.S. Kutateladze SB RAS, Akademika Lavrentiev Ave., 1, Novosibirsk, Russia
  • А. S. Pochtar’ Novosibirsk State Technical University, st. Nemirovich-Danchenko, 136, Novosibirsk, Russia
Keywords: coal, plasma torch, pulverized coal power boilers, flare combustion, ignition and illumination, mechanical activation.

Abstract

This work presents the results of experimental research and industrial application of promising methods of ignition and combustion of coal fuel using mechanochemical and plasma activation. Experimental studies were carried out on a test bench with thermal power of up to 5 MW. Experimental data were obtained on the implementation of the combustion and ignition process using mechanoactivation technologies and a high-voltage AC plasmatron. The introduction and the first industrial tests of a high-voltage AC plasmatron were carried out on a real power boiler TP-10 with a capacity of 220 tons of steam per hour with the replacement of gas and fuel oil with coal during the ignition of the boiler.

References

(1). Hübel M, Meinke S, Andrén MT, Wedding C, Nocke J, Gierow C, Hassel E, Funkquist J (2017) Applied Energy 208(15):319-331.

(2). Makarova AA, Mitrova TA, Kulagina VA (2019) Forecast of energy development in the world and in Russia 2019 [Prognoz razvitiya energetiki mira i Rossii 2019] ERI RAS – Moscow School of Management SKOLKOVO, Moscow, Russia. ISBN 978-5-91438-028-8 (in Russian)

(3). Higman C, van der Burgt M (2003) Gasification 1-391. Crossref

(4). IEA Market Report Series: Coal 2019 Analysis and forecast to 2024. ISSN: 25202723 (online) Crossref

(5). Jacobson MZ (2009) Energy and Environmental Science 2:148–173. Crossref

(6). Chong ZR, Yang SHB, Babu P, Linga P, Li X-S (2016) Applied Energy 162:1633–1652. Crossref

(7). Glushkov DO, Kuznetsov GV, Chebochakova DA, Lyakhovskaya OE, Shlegel NE, Anufriev IS, Shadrin EYu (2018) Applied Thermal Engineering 142:371–379. Crossref

(8). Heimann G, Rediess M (2015) Technische Anforderungen an Braunkohlekraftwerke in der Zukunft. In: Kraftwerkstechnik 2015, SAXONIA Standortentwicklungs und verwaltungsgesellschaft mbH; P.91–101.

(9). Burdukov AP, Popov VY, Faleev VA (2009) Thermal science 1:127–238. Crossref

(10). Burdukov AP, Popov VY, Yusupov TS, Hanjalic K, Chernetsky MY (2004) Fuel 122:127–138. Crossref

(11). Engelsht VS, Desyatkov GA, Musin NU, Saychenko NA (1991) Saving fuel oil with plasma illumination in pulverized coal boilers [Ekonomiya mazuta pri plazmennoj podsvetke v pyleugol’nyh kotlah] Problems of energy saving: Abstracts. report All-Union. scientific-practical conf. Kiev, Ukraina. P.57–58. (in Russian)

(12). Engelsht VS, Desyatkov GA, Larina LT, Musin NU, Okopnik GM, Saychenko AN (1991) Igniter [Zapal’nik]. Patent of the USSR №1040281. (in Russian)

Published
2021-12-25
How to Cite
Alekseenko, S., BurdukovА., ButakovЕ., & Pochtar’А. (2021). COAL IGNITION AND COMBUSTION RESEARCH FUEL WITH MECHANO – AND PLASMA CHEMICAL ACTIVATION FOR ENERGY. Combustion and Plasma Chemistry, 19(4), 237-244. https://doi.org/10.18321/cpc461